2013 POLARIS RZR OWNERS MANUAL PDF

Find replacement and service parts catalogs online for the Polaris RZR, Sportsman, ACE, GENERAL and RANGER by model and year. View and Download Polaris RANGER RZR S service manual online. RANGER RZR S Offroad Vehicle pdf manual download. Also for: ranger. View and Download Polaris RZR owner’s manual online. RZR Offroad Offroad Vehicle Polaris Ranger RZR Owner’s Manual. ( pages).

Author: Mojind Malajinn
Country: Argentina
Language: English (Spanish)
Genre: Photos
Published (Last): 26 April 2012
Pages: 97
PDF File Size: 6.39 Mb
ePub File Size: 5.95 Mb
ISBN: 378-5-95023-111-2
Downloads: 8846
Price: Free* [*Free Regsitration Required]
Uploader: Zolonos

Always be sure that at least five 5 full turns of winch cable are wrapped around the winch drum at all times. Connect the negative – battery cable and install the drivers seat. Fuel Gauge – The 213 of the fuel gauge show the level manul fuel in the fuel tank. Max Tip Clearance 0. Loctite This will prevent any possible damage to the bolts or to the crankcase casting.

Remove Remove Suspension Plate Remove 6. Remove the Torx screws retaining the rear portion of the floor and remove the lower floor from the vehicle.

  BUK100 50GL PDF

Owner’s Manuals | Polaris Off-Road Vehicles

Allow coolant to completely drain. Dealers may not give authorization for export. Page Belt burnt, thin -Dragging brake -Inspect brake system.

ownerrs Before shifting into reverse gear, always check for obstacles or people behind the vehicle. Replace disc if worn beyond service limit.

Page 40 Radiator hose clamp torque is 36 in-lbs 4 Nm.

Page RZR 4: Perform the pre-ride inspection. Serious burns can result from contact with skin, eyes or clothing. Page Wheel Nuts: Remove brake line from caliper.

Cooling System Pressure Test 1. If the boots exhibit any of these symptoms, they should be replaced. PVT outlet duct see page Page 82 Spark plug H Inspect; replace as needed Perform these procedures more often for vehicles subjected to severe use.

Owner’s Manuals | Polaris RZR

With lights on, charging should occur at or below RPM. Use the MODE button to toggle to the odometer display.

Remove the stabilizer bar from the bracket bracket can remain attached to the frame. Remove Brake Line 9. No internal servicing or pplaris may be performed.

  BAKARI KITWANA THE HIP HOP GENERATION PDF

Remove the rocker panel from the vehicle.

Coolant Level Reinstall the cap. Measure the gap between the two rotor tips as shown below. Page 11 Eye Protection Do not depend on eyeglasses or sunglasses for eye protection. Always follow proper operating procedures as outlined in this manual.

Remove the nylon ball retainer.

Polaris 2013 RANGER RZR S Service Manual

Remove excess fluid from reservoir as required. A passenger must always be 0213 in the passenger seat with seat belt secured. Axle Shaft Axle Shaft 7.

Page Once the spider passes the retaining ring notch on the shaft, install the retaining ring. Don’t show me this message again.

Polaris RZR 800 Owner’s Manual

Remove the reverse clutch gear assembly from the housing. Install pilot into valve guide. Transmission And Gearcases 4.